Section 1 - PRODUCT IDENTIFICATION

Product/Chemical Name: PC-1803 (Part A Base)

Manufacturer: Excellent Coatings International, 10880 Poplar Avenue, Fontana, CA 92337

(800) 473-3817 / (909) 357-7215 FAX

Section 2 - HAZARDOUS INGREDIENTS

EXPOSURE LIMITS IN AIR (GIVEN UNITS)

CHEMICAL NAMES	CAS NUMBERS	WEIGHT PERCENT	ACGIH TLV	OSHA PEL	VAPOR PRESSURE mm Hg & Temp. F
LIQUID EPOXY RESINS	MIXTURE.	85-95	N/A	N/A	N/A
ALKYL PHENOL	25154-52-3	6-12	N/A	N/A	<1 68°

Section 3 - PHYSICAL PROPERTIES

VAPOR DENSITY: N/A BOILING POINT OR RANGE, °F: 250°

EVAPORATION RATE: N/A PERCENT VOLATILE BY VOLUME: 0

WEIGHT PER GALLON (LBS.): 9.30± .2

Section 4 - FIRE AND EXPLOSION

Flash Point °f: >200°

FLAMMABLE LIMITS IN AIR, VOLUME %: lOWER (lel) n/a uPPER (uel) n/a

fIRE EXTINGUISHING MATERIALS:

xwATER SPRAY x CARBON DIOXIDE xalcohol foam

x FOAM x DRY CHEMICAL

osha flammabilitty classification: Combustible Liquid, Class IIIB

SPECIAL FIREFIGHTING PROCEDURES: wEAR A niosh/msha APPROVED SELF-CONTAINED BREATHINg APpARATUS AND FULL PROTECTIVE CLOTHING. uSE WATER TO KEEP FIRE EXPOSED CONTAINERS COOL.

UNUSUAL FIRE AND EXPLOSION HAZARDS: Vapors are heavier than air and may travel along the ground or be moved by ventilation to ignition sources at locations distant from material handling point. Pressure may build up in containers and create an explosion hazard.

Section 5 - HEALTH HAZARD INFORMATION

THIS PRODUCT IS COMBUSTIBLE.

SYMPTOMS OF OVEREXPOSURE FOR EACH POTENTIAL ROUTE OF EXPOSURE:

INHALED: VAPORS MAY BE IRRITATING TO RESPIRATORY TRACT, MUCOUS MEMBRANES AND EYES. MAY PRODUCE HEADACHE AND NAUSEA IN POORLY VENTILATED AREAS.

CONTACT WITH SKIN OR EYES: MAY CAUSE EYE IRRITATION, TEARING AND REDNESS. MAY CAUSE IRRITATION OF THE SKIN. REMOVE CONTAMINATED CLOTHING.

ABSORBED THROUGH SKIN: N/A

SWALLOWED: ADOMINAL PAIN, NAUSEA, VOMITING AND DIARRHEA.

FIRST AID EMERGENCY PROCEDURES:

EYE CONTACT: FLUSH WITH WATER FOR 15 MINUTES.

SKIN CONTACT: WASH SKIN WITH SOAP AND WATER.

INHALED: MOVE TO FRESH AIR, AID BREATHING IF NECESSARY

SWALLOWED: DO NOT INDUCE VOMITING.

IN ALL CASES, CONSULT A PHYSICIAN FOR BEST TREATMENT.

SUSPECTED CANCER AGENT?

xNO: THIS PRODUCT'S INGREDIENTS ARE NOT FOUND IN THE LISTS BELOW

¨FEDERAL osha ¨ntp ¨larc

SECTION 6 - REACTIVITY DATA

STABILITY: x STABLE q UNSTABLE

CONDITIONS TO AVOID: ALL SOURCES OF IGNITION

INCOMPATIBILITY (MATERIALS TO AVOID): OXIDING AGENTS, STRONG ACIDS AND BASES.

HAZARDOUS DECOMPOSITION PRODUCTS): CARBON MONOXIDE, CARBON DIOXIDE, NITROGEN OXIDES AND ORGANIC COMPOUNDS.

HAZARDOUS POLYMERIZATION: q MAY OCCUR x WILL NOT OCCUR

SECTION 7 - SPILL, LEAK, AND DISPOSAL PROCEDURES

SPILL RESPONSE PROCEDURES (INCLUDE EMPLOYEE PROTECTION MEASURES): DIKE SPILL AREA. ABSORB SPILL WIH INERT ABSORBENT MATERIAL.

PREPARING WASTES FOR DISPOSAL (CONTAINER TYPES, NEUTRALIZATION, ETC.): PLACE IN SEALED METAL CONTAINERS FOR PROPER DISPOSAL.

NOTE: DISPOSE OF ALL WASTES IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.

SECTION 8 - SPECIAL HANDLING INFORMATION

VENTILATION AND ENGINEERING CONTROLS: GENERAL (MECHANICAL) ROOM VENTILATION IS EXPECTED TO BE SATISFACTORY. USE LOCAL EXHAUST IF NEEDED TO CONTROL VAPORS OR MIST.

RESPIRATORY PROTECTION (TYPE): USE MSHA/NIOSH - APPROVED RESPIRATOR IN POORLY VENTILATED AREAS WHERE EXPOSURE LIMITS ARE EXCEEDED.

EYE PROTECTION (TYPE): CHEMICAL SPLASH GOGGLES AND AVAILABLE EYE BATH.

GLOVES (SPECIFY MATERIAL): USE IMPERVIOUS GLOVES.

OTHER CLOTHING AND EQUIPMENT: PROTECTIVE CLOTHING, BARRIER CREAM, EYE BATH, SAFETY SHOWER.

WORK PRACTICES, HYGIENIC PRACTICES: USE WITH ADEQUATE VENTILATION. AVOID CONTACT WITH SKIN AND EYES. MINIMIZE CONTACT. AVOID BREATHING VAPORS

OTHER HANDLING AND STORAGE REQUIREMENTS: STORE IN DRY AREA. KEEP AWAY FROM OPEN FLAMES AND HIGH TEMPERATURES.

PROTECTIVE MEASURES DURING MAINTENANCE OF CONTAMINATED EQUIPMENT: N/A